Product ID:ROYCO 36
MSDS Date:02/01/1999
FSC:9150
NIIN:01-104-5227
MSDS Number: BRQGN

ROYAL LUBRICANTS COMPANY INC.

MERRY LN
EAST HANOVER, NJ 07936
US

Emergency Phone: 973-887-7411

Info Phone: 201-887-7410/201-887-8404

Preparer: PRODUCT SAFETY

Cage: 07950

SDB CONSULTANTS LTD

GRETNA, LA 70056 US

Telephone: 504-366-9105

Cage: 0PGK2

SYNTHETIC ESTER

CAS: 109-32-0

SYNTHETIC ESTER

CAS: 26719-40-4

SILICONE/PHENYLMETHYLSILOXANE

CAS: 63148-52-7

LEAD DINONYLNAPHTHALENE SULFONATE

CAS: 63568-30-9

ANTIMONY O,O'-DI-N-PROPYL PHOSPHORODITHIOATE

CAS: 15874-48-3

OTHER COMPONENTS

2-MERCAPTOBENZOTHIAZOLE

CAS: 149-30-4

RTECS: DL6475000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE SPECIFIED BY
MANUFACTURER. ACUTE: EYES-MAY BE MILDLY IRRITATING TO EYES.
SKIN-RELEASE DURING HIGH PERSSURE USAGE MAY RESULT IN INJECTION
INTO SKIN CAUSING LOCAL NECROSIS. PROLONGED OR REPEATED CONTACT
MAY CAUSE ALLERGICSENSITIZATION AND MAY LEAD TO ABSORPTION OF LEAD.
INHALATION- NOT EXPECTED TO BE A RELEVANT ROUTE OF EXPOSURE;
HOWEVER, UNDER HIGH TEMERATURE CONDITIONS, VAPORS IRRITATING TO
NOSE, THROAT & UPPER RESPIRATORY MAY BE PRODUCED.
INGESTION-MAYRESULT IN ABSORPTION OF LEAD.
Explanation of Carcinogenicity:NTP HAS DEMONSTRATED
MERCAPTOBENZOTHIAZOLE, 2 TO BE CARCINOGENIC.
Effects of Overexposure:IRRITATION AS NOTED IN ACUTE/CHRONIC HEALTH
SECTION. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN AND
TISSUE DAMAGE A FEW HOURS OF INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS OR EYE
PROBLEMS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:INHALED: MOVE TO FRESH AIR. PROVIDE OXYGEN IF NEEDED. EYES:
FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHES. WIPE OFF EXCESS. WASH
SKIN WITH SOAP & WATER. IF INJECTED UNDER SKIN, SEE PHYSICIAN
PROMPTLY.INGESTED: DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT
IS NECESSARY UNLESS LARGE QUANTITIES OF PRODUCT ARE INGESTED.
HOWEVER, GET MEDICAL ADVICE. INHALED: REMOVE VICTIM TO FRESH AIR &
PROVIDE OXYGEN IF BREATHING DIFFICULT. GET MEDICAL ATTENTION.

Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:UNKNOWN.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
WITH ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:AVOID SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET. LAUNDER CONTAMINATED
CLOTHERS BEFORE REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER
ARTICLES, INCLUDING SH OES, THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:NITRILES IF PROLONGED/REPEATED CONTACT
Eye Protection:GOGGLES IN HIGH PRESSURE APPLICATIONS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN HIGH
VISCOSITY, LOW VOLATILITY PRODUCTS, I.E., MOST OILS AND GREASES.
FORMULA CHANGED.

HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN, SEMI-FLUID WITH SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:CONTACT WITH OPEN FLAMES, HEAT.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPOUNDS MAY FORM.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:THIS PRODUCT CONTAINS LEAD. DISPOSE OF AS
REQUIRED FOR MATERIALS CONTAINING EXTRACTABLE LEAD UNDER US EPA
REGULATIONS.

Toxicological Information:OSHA/PEL OR ACGIH/TLV HAS BEEN ESTABLISHED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:EPA-CLEAN WATER ACT (CWA): THIS PRODUCT IS CLASSIFIED AS AN
OIL UNDER SECTION 311 OF THE CLEAN WATER ACT. SPILLS ENTERING
SURFACE WATERS OR ANY WATERCOURSES OR SEWERS ENTERING/LEAVING TO
SURFACE WATER S THAT CAUSE A SHEEN MUST BE REPORTED TOTHE NATIONAL
RESPONSE CENTER, 800-424-8802.

Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY DOT REGULATIONS.

SARA Title III Information:UNDER SARA TITLE III, SECTION 3123, THIS
PRODUCT CONTAINS LEAD COMPOUNDS AND ANTIMONY COMPOUNDS.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
MERCAPTOBENZOTHIAZOLE, 2-IS THE SUBJECT OF A TSCA SECTION 4 TEST
RULE. EXPORT OF THIS PRODUCT IS THEREFORE P ROHIBITED WITHOUT
NOTIFICATION TO EPA.
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.